|
1. |
Engine - renew engine and oil filter |
|
|
2. |
Automatic transmission - check fluid lever
and correct as necessary |
|
|
3. |
Rear axle - check and adjust oil lever as
necessary |
|
|
4. |
Rear half shaft - examine condition of
seal covering ball and trunion joints.
Check condition of niversal joints and lubricates. |
|
|
5. |
Brake linkage - check condition of linkage
and lubricate clevis and fulcrum pins of parking brake mechanisms.
Lubricate inner cable, clean and oil levers and linkages |
|
|
6. |
Control linkages - lubricate gear range
linkage |
|
|
7. |
Clean and lubricate height control valve
operations rods/levers |
|
|
8. |
Steering linkage - grease steering an
suspension |
|
|
9. |
Steering system - check for leaks. Check
and correct power steering fluid lever |
|
|
10. |
Body - lubricate - locks - bonnet - fluid
filter flap hinges |
|
|
11. |
Clean and reset spark plugs |
|
|
12. |
Carburettors - clean air valve an dampers.
Top up with oil, lubricate linkages |
|
|
13. |
Check idle speed and adjust if necessary.
Replace contacts points if fitted and adjust gap. Check and adjust
ignition as neccessary |
|
|
14. |
Ignition Distributor - lubricate as
necesseary. Replace contact points if fitted and adjust gap. Check and
adjust ignition as necessary |
|
|
15. |
Check condition of rear axle carrier.
Torque arms and mounts |
|
|
16. |
Check condition of frontsuspension bearing
pins and ball joints |
|
|
17. |
Brakes - inspect foot brake and parking
brake pad-linings. When changing brake pads examine condition of dust
excluders on calliper pistons, replace if damaged |
|
|
18. |
Manually adjust parking brake pads |
|
|
19. |
Fuel pumps - check operation of pumps
independently |
|
|
20. |
Clean and drain holes in the bottom of the
sills, rear wings an valance. Clean jacking points |
|
|
21. |
Test engine oil lever indicator |
|
|
22. |
Battery - check level - clean and seal
terminals. Check fixing/mount |
|
|
23. |
Check condition of all vee drive belts,
adjust if necessary |
|
|
24. |
Air silencer - Remove and clean filter
element |
|
|
25. |
Check conditions of cooling fan viscous
coupling |
|
|
26. |
Windscreen washer - check fluid lever and
correct with solvent mixture if necessary |
|
|
27. |
Engine cooling system - check all hoses,
tighten all hose clips. Top up system with correct strength anti-freeze
solution if necessary |
|
|
28. |
Heating and ventilation system - check all
controls operate satisfactory, lubricate where required |
|
|
29. |
Check heater flaps bushes - replace if
necessary |
|
|
30. |
Air conditioning system - check correct
operation, delay temperature etc |
|
|
31. |
Electrical systems - check operation of
all lamps and instruments, rectify any faults |
|
|
32. |
Check - door locking and seat adjustment
operation |
|
|
33. |
Check operation of all seatbelts; check
tightness of securings bolts |
|
|
34. |
Check operation o radio and cassette
system on all speakers, clean and lubricate Arial |
|
|
35. |
Check condition of wheels and tyres (including
spare wheel). Check and adjust tyre pressure. Grease spare wheel carrier
hinges lowering bolt |
|
|
36. |
Check condition of wipers and washers (including
headlamp wash wipe) Replace if necessary |
|
|
37. |
Check vehicle over, report any defects,
including exhaust body mounts, body condition and subframe mountings and
brackets |
|
|
38. |
Waxoil all brake and fuels pipes. Inspect
all brake, fuel, steering. gearbox, pipes and connections |
|
|
39. |
Have vehicle road tested |
|
|
40. |
Check operation of speed hold |
|
|
41. |
Clean vehicle ready for its return to the
owner |
|